|
ASPIRE
-
Check idle speed every 50,000 km
-
Inspect ignition timing 100,000 km
-
Replace cam shaft belt 100,000 km
FOCUS, ZX2,
CONTOUR, MYSTIQUE, COUGAR (2.0 L), ESCORT, RANGER (2.3 L & 2.5
L), ESCAPE (2.0 L)
ESCORT/TRACER
(1.8 L)
-
Check idle speed every 50,000 km
-
Replace cam shaft belt 100,000 km
PROBE (2.0 L
& 2.5 L)
-
Check idle speed every 50,000 km
-
Replace cam shaft belt 100,000 km
COUGAR
TAURUS SHO/VILLAGER
-
Check battery electrolyte level every 40,000 km
-
Replace cam
shaft belt and adjust valve clearance every 160,000 km
LINCOLN LS
E & F SERIES,
EXPEDITION, NAVIGATOR, EXPLORER, RANGER, EXCURSION,
EXPLORER
SPORT TRAC
-
Inspect/adjust 4X2 wheel bearings for end play
every 50,000 km (if serviceable)
-
Lubricate 4X2 wheel bearings every 100,000 km (if
serviceable)
-
Replace manual transmission fluid every 100,000
km
-
Replace fuel filter every 20,000 km
-
Replace climate-controlled seat filters every
50,000 km (Navigator if equipped)
4X4 VEHICLES
-
Lubricate transfer case shift lever pivot bolt
and control rod connecting pins
every 20,000 km
-
Replace transfer case fluid every 100,000 km
-
Lubricate front axle RH axle shaft slip yoke
every 50,000 km
-
Inspect and lubricate spindle needle bearings
every 50,000 km (if serviceable)
-
Inspect and lubricate hub locks every 50,000 km
(if serviceable)
-
Replace
front axle lubricant every 250,000 km
SUPER DUTY,
F-SUPER DUTY
-
Inspect parking brake fluid level every 20,000 km
-
Replace rear axle lubricant every 50,000 km
(F-450, F-550)
-
Replace manual transmission fluid every 100,000
km
-
Replace fuel filter every 20,000 km
-
Retorque dual rear wheels after 160 km of
service, then 800 km later; repeat
sequence after
-
any rear wheel removal or tire rotation
-
Check spring
U-bolt torque every 5,000 km
OFF-ROAD USE
(EVERY 5,000 KM)
-
Multi-point inspection
-
Inspect and lubricate hub locks
-
Inspect and lubricate automatic transmission,
transfer case and clutch
linkages
-
Check spring U-bolt torque
-
Inspect the differential vent hose
-
Check axle fluid for water contamination and
change fluid if necessary
-
Repack front wheel bearings and hubs (where
serviceable)
-
Lubricate spindle needle bearings (4X4)
-
Brake inspection
-
Thoroughly
clean underbody as required
DIESEL ENGINE
(ALSO REFER TO DIESEL SUPPLEMENT IN THE OWNER'S GUIDE FOR
ADDITIONAL REQUIREMENTS)
-
Add CFW76 Coolant Conditioner, if equipped with
"green" coolant,
-
every 12 months
or 20,000 km (whichever occurs first)
-
Check air filter minder every 5,000 km; replace
air filter as required
-
Replace fuel filter every 20,000 km
-
Drain water from fuel filter reservoir every fuel
fill-up
-
Inspect air
filter daily in dusty conditions and replace if necessary
MOTORHOME/RECREATIONAL/AMBULANCE/E-550
ALTERNATIVE
FUEL VEHICLES (NATURAL GAS VEHICLES [CNG], PROPANE, FLEX FUEL)
-
For CNG and propane vehicles, drain coalescer and
replace O-ring seal
-
and fuel
filter every 50,000 km
-
Inspect CNG fuel tank every 3 years from the date
of tank manufacture,
-
at
Ford approved gaseous fuel dealers
-
Inspect propane fuel tank every 5 years from the
vehicle build date,
-
at Ford approved
gaseous fuel dealers
-
Replace CNG tanks every 15 years from the date of
tank manufacture
-
Change engine oil every 5,000 km if you operate a
flex fuel vehicle using
-
E-85 fuel
more than 50% of the time.
Please Note
-
Varied driving
habits, dust and road conditions may require more frequent
replacement of wear components than the time/distance intervals
shown in this publication.
-
If you are using
your Ford vehicle in a stationary manner while the engine is running
for 'On' periods (i.e. door-to-door delivery, taxi, police,
power/utility, power take-off (PTO) use), change your oil and filter
every 5,000 km or every 200 engine hours. It will be necessary to
approximate idle time on vehicles not equipped with hour meters.
-
The required
maintenance services listed are subject to change without notice.
|
Additional Info 
